Ya-Fen Wang1, Hsing-Yuan Yen2, Ying I. Tsai3, Hong-Miao Chen4, Cheng-Hsien Tsai 4

  • 1 Department of Bioenvironmental Engineering, Chung Yuan Christian University, Chung-Li, Taiwan
  • 2 Department of Chemical and Biochemical Engineering, Kao Yuan University, Kaohsiung, Taiwan
  • 3 Department of Environmental Resources Management, Chia Nan University of Pharmacy and Science, Tainan, Taiwan
  • 4 Department of Chemical and Material Engineering, National Kaohsiung University of Applied Sciences, 415 Chien-Kung Road, Kaohsiung 807, Taiwan

Received: October 6, 2012
Revised: February 4, 2013
Accepted: February 4, 2013
Download Citation: ||https://doi.org/10.4209/aaqr.2012.10.0269  

  • Download: PDF

Cite this article:
Wang, Y.F., Yen, H.Y., Tsai, Y.I., Chen, H.M. and Tsai, C.H. (2013). Rapid Thermal Synthesis of Nano Titanium Dioxide Powders Using a Plasma Torch. Aerosol Air Qual. Res. 13: 1313-1320. https://doi.org/10.4209/aaqr.2012.10.0269



Spherical TiO2 nano- to microparticles are rapidly synthesized by spraying clear stock solution as a nano aerosol into an atmospheric-pressure microwave plasma torch at 550–600°C. The stock solution was prepared by an initial H2O/TiCl4 (titanium tetrachloride) volume ratio of 8. At about 0.15 s, anatase TiO2 powders were produced and collected by 14-stage impactors. The size distribution shows that 98.47% of the particles in number were in the < 10-nm impactor, with the normalized particle number percentage (dn'/dlogDp) of 327.1, although the mass distribution of the powders was mainly in the size range of 2.5–6.2 μm. Scanning electron microscopy and transmission electron microscopy images show that most of the spherical TiO2 particles had a primary particle size of about 10 nm. Moreover, larger secondary particles (several μm), likely aggregated small particles were also presented. The chemical composition and elemental analyses show that the structure of the powders is mainly composed of TiO2 with traces of TiO2-xNx. Hence, the total reaction pathway is proposed as Ti(OH)xCl4-x + H2O + N2 + O2 → TiO2 nuclei + HCl + other byproducts. Moreover, the ultraviolet-visible absorption spectrum and photocatalytic performance of the synthesized powders during exposure to ultraviolet or visible light are comparable to those of commercial TiO2 powders.

Keywords: Nanoparticles; Size distribution; Synthesis; Photocatalyst; Discharge

Don't forget to share this article 


Subscribe to our Newsletter 

Aerosol and Air Quality Research has published over 2,000 peer-reviewed articles. Enter your email address to receive latest updates and research articles to your inbox every second week.

Latest coronavirus research from Aerosol and Air Quality Research

2018 Impact Factor: 2.735

5-Year Impact Factor: 2.827

SCImago Journal & Country Rank

Aerosol and Air Quality Research (AAQR) is an independently-run non-profit journal, promotes submissions of high-quality research, and strives to be one of the leading aerosol and air quality open-access journals in the world.